Attic Furnace Condensation

In the attic i always recommend a float switch installed in the secondary air conditioning condensation drain pan.

Attic furnace condensation. Condensate line in attic furnaces. So here is my question. This is what a service tech did to the vent. Well mainly it s a way to save space.

If you don t have a crawl space or a basement then it can be a challenge to place a furnace on the ground floor of the structure. Because entire central air system is lying on its side in the event of condensate drain pan failure water does not drip in one general location. That moisture can freeze if it receives exposure to. You might not receive the same air movement benefits if the unit is in a garage either.

While i suggested they may have been not able to perform due to extreme cold conditions we then got onto him going back to 80 furnaces which i do not want to encourage. When you see water puddling around the furnace with the a c running you have a clogged condensate drain tube. Improper or no insulation of ducts. Condensation from air conditioning coils contains bacteria that can form slime and clog the condensate pan drain tube.

Sometimes attic condensation is the result of an attic being improperly ventilated. The simple physics behind sweating is. So why put an hvac system up in the attic at all. Whenever there is a contact between the hot humid air and cold metal surface then there will be sweating or condensation on the metal surface so it is very important to have a proper insulation for the air handler ducts in case the portion of the duct is coming in contact with the.

A furnace in the attic is a design that works for all homes. However an attic in pensacola florida is likely to have a humidity level closer to 100 and the risk of condensation on ductwork would then go up quite a bit. Adding a few vents to the floor of the attic that extend to the ceiling of the story below the attic can help to promote air flow within the attic. This air flow can cut down on condensation.

For furnaces in the attic there is a second condensate drain pan. This is in place as an added layer of protection against water damage. I am a hers rater and one of my builders said he received callbacks 15 homeowners on completed homes with 95 furnaces in unconditioned cold attics this past week. Can a condensate line coming off of the furnace to the floor drain have it s vent pipe covered with duct tape on the top.

If the secondary condensation pan fills the float switch will rise and cut the whole air conditioning unit off. So far i only get the run around and no answer. In order to boost air flow one can install an attic fan. Save money on your new air conditioner or furnace.

I have been trying to get an answer from the furnace company as to why this was done. You can prevent slime and eliminate drain tube clogs in two easy steps. An outdoor unit which houses the fan condenser and compressor and an indoor unit which holds the evaporator and fan. Attic hvac systems save space.